Kansas State University

  1. K-State Home
  2. »Agronomy Home
  3. »K-State Agronomy eUpdates eUpdates
  4. »eUpdate 430 November 15th, 2013»Tips to minimize storage loss of large round bales

K-State Agronomy eUpdates eUpdates

Department of Agronomy

Kansas State University

1712 Claflin Rd.

2004 Throckmorton PSC

Manhatan, KS 66506

785-532-6101

agronomy@ksu.edu

Extension Agronomy

Tips to minimize storage loss of large round bales

Although large round bales reduce labor requirement when putting up hay, storage losses with large round bales are generally much higher than with small rectangular bales, particularly when stored outdoors. This indicates that a lot of large round bales might have some nutrient loss from precipitation combined with air temperature and humidity. Much of the dry matter loss with outdoor storage is associated with microbial respiration under optimal moisture, temperature, and nutrient condition for microbes. The following are a number of ways to minimize large round bale loss stored outside:

  1. Increase bale density

One of the most important ways to reduce round bale loss is to tighten the outer layer of bale. If the bale is not tight enough, microbes are going to use oxygen to break down the bale using moisture and nutrients. If you can depress the surface more than a half inch, the round bale could experience significant loss when placed outside and unprotected. It’s recommended to have a minimum density of 10 lbs of hay per cubic ft.

2. Use covers

Round bales stored outside and covered with either plastic or canvas generally experience much less deterioration than unprotected bales. Weathering can reduce forage quality of round bale hay, particularly digestibility. Plastic wrap, net wrap, reusable tarps, or plastic twine can be used to prevent the loss from weathering. Plastic wrap or net wrap will result in less loss than twine.

Figure 1. Sorghum-sudangrass bale wrapped with a net. Photo by Doo-Hong Min, K-State Research and Extension.

 

3. Select a good storage site

Selecting a good storage site is another important consideration in reducing bale loss with little cost involvement. First of all, the storage site should not be shaded and should have good air circulation, which will enhance drying conditions. The storage site also should be well-drained to reduce moisture absorption into the bottom side of the round bales. A well-drained, 4 to 6 inch coarse rock base would help minimize bottom spoilage of a large round bale. Bale storage loss can be reduced by elevating the bales rather than placing them on the ground. Ground contact can account for over half of the total dry matter loss. To elevate the bales from the ground use racks, fence posts, discarded pallets, railroad ties, used tires, or a layer of crushed rock about 4 to 6 inches deep to have good drainage.

4. Orient rows of bales to promote good drying

It’s recommended to stack large round bales in rows, buff end-to-end, give three feet between rows, and orient the rows in a north-south direction. This will allow the area to dry faster after a rain by having good sunlight and air flow. Vegetation between rows should be mowed to allow good air flow.

Figure 2. Large round bales should be stacked in rows in a north-south orientation. Photo by John Holman, K-State Research and Extension.

5. Environment makes a difference

Storage loss coincides with precipitation amount. Storage loss in eastern Kansas is much greater than in western Kansas. Bales can be stored outside in western Kansas for a couple of years before much significant loss will occur, but storage loss can be significant in eastern Kansas after just one year of outside storage. Rarely would indoor storage pay for itself in western Kansas, but storing high quality/high value forage in eastern Kansas might justify the expense of storing hay under cover.

               

Doo-Hong Min, Southwest Area Crops and Soils Specialist
dmin@ksu.edu

John Holman, Cropping Systems Agronomist, Southwest Research-Extension Center
Jholman@ksu.edu

Jim Shroyer, Crop Production Specialist
jshroyer@ksu.edu